Insulation Oil Separators Purifier System
1.Eliminating the liquid water quickly
2.Purifying and drying Transformer Oil
Ultra-high Voltage Insulation Oil Separators Purifier System with
high oil out rate,tubes design,environmental
Especially for ultra-high voltage project as ( 1000KV,±800KV, 750KV,±660KV)
Our Double Stage Transformer Oil Filtration Plant is the solution
to your on site transformer oil maintenance, the filtering of
transformers is one of the least expensive, best known ways of
preserving the life of the unit.
When it comes to transformer oil processing TOP have the equipment,
experience and skilled personnel to perform oil processing on your
power transformers, safely and efficiently. From vacuum filling to
hot oil cleaning we can handle the project
The plant can be used to process oil for the initial fill, after
maintenance refill or as a process to keep all your oil filled
equipment in optimum operating condition.
Oil Purifier Features:
1. Two pumps: Vacuum pump and booster pump2. Three-stage filter system3. Z-shape Heater to make the heating uniformity4. Installing oil-level floating ball and double-infrared liquid
level automatic controller to control the oil level5. Foam sensor to avoid oil leaking6. Temperature Controller to protect the machine7. Suitable oil filtration machine for high voltage transformer8. Large filtration area, high capacity of holding impurities9. Two vacuum separator to increase separating size and time and
ensure the drying degree and improve dielectric strength which is
higher than 75 KV.10. Doing online oil purification of substations over 110 KV.11. Independent function of vacuum oil filling and drying.12. Duplex stereo flash evaporation technology13. Equipped with pressure protective system and interlocked
protective system to connect oil pump, heater and liquid level
controller. If there has any fault, this oil filter will be power
off automatically.14. Saving energy and time
Benefits of transformer Oil Filtration/Purifier
1.The conventional process of transformer oil exchange is time
consuming, costly and not environmentally friendly.
2.Our mobile oil purification plants can regenerate the oil on site
and in most cases while the transformer is online. This means there
will be no production outages for you.
3.It will also be 30 to 60% cheaper to purify the transformer oil
compared to exchanging the oil.
4.The process of oil purification not only restores the oil
properties, but also cleans the inside of the transformer of all
decay products, which would not happen if the oil was merely
Three Phase 50Hz,380V (or as needed)
The oil technical data after treatment:
1. Gas content is less than 0.1%
2. Impurity size is less than 1μm without free carbon
3. Water content is less than 3 part per million
3. Oil dielectric strength (breakdown voltage) is more than 75KV
4. Acidity value is less than 0.01 mg KOH/g
5. Dielectric loss factors at 90°C is less than 0.001
Company main products:
1. Transformer Oil Purifier:
This kind of machine is used to purify used transformer oils by
vacuum separation technology to remove water, gas, particles.
2. Lube Oil Purifier:
This machine is to filter used lube oils, such as hydraulic oil,
gear oil and other lubricants.
It can effectively break emulsification and completely remove
water, gas, particles.
3. Cooking oil recycling machine:
This machine is used to recycle waste cooking oil, dirty vegetable
oil, drainage oil, swill oil and animal oil etc., it effectively
and completely removes particles, odor, water, gas, etc. from waste
oil. The treated oil is clean and good smell.
4. Transformer Oil BDV Tester:
This tester with automatic operation system is ued to online
monitor transformer oil's dielectric strength.
5. Oil Water Content Testing Machine:
This device is designed to test water content in oil to make sure
the oil is suitable for further use.
If you have any requirements,please do not hesitate to contact me